egoidealmusic Posted November 15, 2023 Share Posted November 15, 2023 So, I just noticed that there are a couple a very fine cracks on the bridge of my J-45 between a few of the pins--the most noticeable between the A and the D pins. While the humidity in this area is generally very high (I'm in Georgia just above the Florida line) I put her back in the case with a humidifier. Seems like it's closed up a good amount but obviously I'm concerned (she's only about 2 1/2 years old). Reading elsewhere it seems that lots of folks suggest water thin CA glue is the best fix as it doesn't seem massive and all the way through the bridge, but I'm curious as to your sage thoughts. No authorized Gibson repair shop anywhere near me, so I'd have to send it to Gibson if I had to. Quote Link to comment Share on other sites More sharing options...
Sgt. Pepper Posted November 16, 2023 Share Posted November 16, 2023 17 hours ago, egoidealmusic said: So, I just noticed that there are a couple a very fine cracks on the bridge of my J-45 between a few of the pins--the most noticeable between the A and the D pins. While the humidity in this area is generally very high (I'm in Georgia just above the Florida line) I put her back in the case with a humidifier. Seems like it's closed up a good amount but obviously I'm concerned (she's only about 2 1/2 years old). Reading elsewhere it seems that lots of folks suggest water thin CA glue is the best fix as it doesn't seem massive and all the way through the bridge, but I'm curious as to your sage thoughts. No authorized Gibson repair shop anywhere near me, so I'd have to send it to Gibson if I had to. Is it cracked fully between where the A and D string pins go? Quote Link to comment Share on other sites More sharing options...
egoidealmusic Posted November 16, 2023 Author Share Posted November 16, 2023 Yes, there's a faint crack line between them. Very tight crack so I don't think it's all the way through. Quote Link to comment Share on other sites More sharing options...
the other side Posted November 17, 2023 Share Posted November 17, 2023 13 hours ago, egoidealmusic said: Yes, there's a faint crack line between them. Very tight crack so I don't think it's all the way through. Might try putting some lemon oil on it you use on the fretboard. Quote Link to comment Share on other sites More sharing options...
zombywoof Posted November 17, 2023 Share Posted November 17, 2023 (edited) I have been told this kind of hairline crack can be caused by pushing something like bone pins in too far. As you note, the repair is easy. Pretty much some thin CA glue with ebony or rosewood dust mixed in. Edited November 17, 2023 by zombywoof Quote Link to comment Share on other sites More sharing options...
fortyearspickn Posted November 17, 2023 Share Posted November 17, 2023 I'm sure you've done this already - but there are good YouTube videos on the best way to seal and bond hairline wood cracks with SuperGlue. I'd make sure the crack was reasonably wide before inserting glue so it could get down there. Not to quibble, but I'd not put lemon oil in there before the glue. And I'd only sprinkle very fine dark wood dust on top when your done, not mix it in with the glue going down into the crack. And, I'd double check when I do string changes that the ball of the string is properly seated. And the holes in the bridge plate aren't chewed up or too large. Certainly shouldn't be in a 2 year old guitar. Sorry to hear this - the good news is you caught it in time ! G'Luck !! Quote Link to comment Share on other sites More sharing options...
Murph Posted November 17, 2023 Share Posted November 17, 2023 I would be very sparingly using any oil on any wood that is glued. Oil tends to make glue release from wood, which is bad. Quote Link to comment Share on other sites More sharing options...
egoidealmusic Posted November 17, 2023 Author Share Posted November 17, 2023 Thanks for the input, folks. The pins are the exact size as those it originally came with, so that's not causing it. I do use a little lemon oil each time when I change strings--about every 3 months. I have watched a number videos and am comfortable working on my guitars. Am planning on doing this tomorrow and will update. Quote Link to comment Share on other sites More sharing options...
egoidealmusic Posted November 19, 2023 Author Share Posted November 19, 2023 So after a week in the case wtih the humidy packs the crack has closed up. There was still a slightly visible line but totally closed. I gave it a couple of coats of the water thin CA glue along the crack lines, let it dry then sanded down with 1200 grit paper. Gave it some lemon oil and it's looking great. Letting any glue that might have seeped in (very little seemed to though) cure for a day before I string her up. Thanks again for the advice! Quote Link to comment Share on other sites More sharing options...
Recommended Posts
Join the conversation
You can post now and register later. If you have an account, sign in now to post with your account.